Korean Journal for Food Science of Animal Resources

pISSN 1225-8563 eISSN 2234-246X

Korean J. Food Sci. An. 37(1): 147~152 (2017) DOI https://doi.org/10.5851/kosfa.2017.37.1.147


Monitoring of Bioluminescent Lactobacillus plantarum in a Complex Food Matrix Gi-Seong Moon* and Arjan Narbad1 Department of Biotechnology, Korea National University of Transportation, Jeungpyeong 27909, Korea 1 Gut Health and Food Safety Programme, Institute of Food Research, Norwich NR4 7UA, UK

Abstract A bioluminescent Lactobacillus plantarum (pLuc2) strain was constructed. The luminescent signal started to increase during the early exponential phase and reached its maximum in the mid-exponential phase in a batch culture of the strain. The signal detection sensitivity of the strain was the highest in PBS (phosphate buffered saline), followed by milk and MRS broth, indicating that the sensitivity was influenced by the matrix effect. The strain was used in millet seed fermentation which has a complex matrix and native lactic acid bacteria (LAB). The luminescent signal was gradually increased until 9 h during fermentation and abolished at 24 h, indicating that the strain could be specifically tracked in the complex matrix and microflora. Therefore, the bioluminescent labeling system can be used for monitoring LAB in food and dairy sciences and industries. Keywords bioluminescence, luciferase, monitoring, Lactobacillus plantarum, complex matrix


Received Revised Accepted

January 31, 2017 February 8, 2017 February 14, 2017

*Corresponding author Gi-Seong Moon Department of Biotechnology, Korea National University of Transportation, Jeungpyeong 27909, Korea Tel: +82-43-820-5251 Fax: +82-43-820-5272 E-mail: [email protected]

Lactic acid bacteria (LAB) have been historically recognized as health promoting bacteria in humans and are widely used as probiotics (de Vos, 2011). In general, LAB exhibit beneficial properties such as anti-diarrheal (Katz, 2006), anticonstipation (Higashikawa et al., 2010), anti-cancer (Riaz Rajoka et al., 2017), and immune stimulation (Tsai et al., 2012), and many LAB are anti-pathogenic bacteria (Sanz et al., 2007). Recently, LAB have attracted interest as bacteria beneficial for gut health since it has been revealed that the gut microbiome is deeply correlated with human physiology (D'Argenio and Salvatore, 2015). Tsai et al. (2014) observed that some LAB strains can modulate the human gut microbiota, which has an influence on the anti-obesity effects as part of metabolic disease prevention. Diets including prebiotics, probiotics, and fermented foods can also modulate the human gut microbiota which has an influence on the enteric and the central nervous systems, resulting in improvement of brain functions (Galland, 2014). Besides the probiotic effects of LAB, they have been used as starter cultures for various fermented foods including yogurt, sausage, etc. (Ammor and Mayo, 2007; Morelli, 2014) in many different countries throughout the world. Most of the starter cultures used in monoculture fermentations are characterized during fermentation and the processes are well established. However, novel LAB strains for starter culThis is an open access article distributed under the terms of the Creative Commons Attribution Non-Commercial License (http://creativecommons.org/licences/by-nc/3.0) which permits unrestricted non-commercial use, distribution, and reproduction in any medium, provided the original work is properly cited.

Copyright © Korean Society for Food Science of Animal Resources


Korean J. Food Sci. An., Vol. 37, No. 1 (2017)

tures that have potential for use in complex food matrices harboring their own indigenous microbial communities are more difficult to follow during the fermentation processes. Reporter proteins such as green fluorescent protein (GFP) and luciferase (Luc) have been used for labeling the bacteria to monitor them in vitro, in situ, and in vivo (Gory et al., 2001; Karimi et al., 2016; Ninomiya et al., 2013; Phumkhachorn et al., 2007). Since these proteins can produce fluorescent and luminescent signals, respectively, in a complex situation, the labeled bacteria can be tracked without culturing for enumeration (Daniel et al., 2015; Yu et al., 2007). Food microbiologists have questioned the behavior of starter cultures or survivability during the fermentation process. In this study, we have tried to track a bioluminescent Lactobacillus plantarum strain during millet seed fermentation where native LAB strains were also cultivated.

Materials and Methods Bacterial strains and culture conditions L. plantarum ULAG11 strain originally isolated from fermented kunu-zaki in Nigeria (Oguntoyinbo and Narbad, 2012) was a gift from Prof. Folarin Anthony Oguntoyinbo working at the Department of Microbiology in University of Lagos (Nigeria). The strain was cultured at 37oC in MRS broth (De Man, Rogosa, and Sharpe; Difco, USA) without shaking. The recombinant L. plantarum ULAG11 (pLuc2) was cultured at 37oC in MRS broth supplemented with 5 µg/mL of erythromycin (Sigma, UK). Transformation Transformation of L. plantarum ULAG11 strain with a recombinant plasmid pLuc2 (Eom et al., 2015), which was developed for lactobacilli bioluminescent labeling, was performed according to the method described in a previously published paper (Moon et al., 2008). The recombinant L. plantarum ULAG11 (pLuc2) strain was selected on the MRS agar plate supplemented with 5 µg/mL of erythromycin (Sigma). Transformation efficiency was 9.6 × 102 cells/µg DNA. Measurement of Bioluminescence To confirm a luminescent signal from the L. plantarum ULAG11 (pLuc2) strain, a luciferase assay system (E1500; Promega, USA) was used according to the manufacturer’s instructions with modification. Namely, 200 µL of exponential phase culture was centrifuged at 13,000 rpm 148

and resuspended with 20 µL of PBS (phosphate buffered saline; Sigma) and mixed with 100 µL of luciferase assay reagent. The mixture was loaded into a black Costar flat bottom 96-well microplate (Corning, USA) and luminescence was measured by using BMG FLUOstar OPTIMA Microplate Reader (BMG LABTECH GmbH, Germany) according to the manufacturer’s instructions. The parent L. plantarum ULAG11 was used as a negative control. Measurement of luminescence during cultivation The L. plantarum ULAG11 (pLuc2) strain was cultured in 100 mL of MRS broth and MRS broth supplemented with 5 µg/mL of erythromycin (Sigma). At the indicated times (0, 2, 4, 6, 8, 10, and 24 h), the cultures were sampled and optical density at 600 nm and luminescence were measured. L. plantarum ULAG11 was cultured in MRS broth alone and used as a negative control. Matrix effect on bioluminescence To investigate luminescence detection sensitivity, 3 different dilution solutions, PBS, MRS broth, and whole milk were tested. L. plantarum ULAG11 (pLuc2), harvested during exponential phase was serially two-fold diluted in each matrix and luminescence was measured as described above. Monitoring of L. plantarum ULAG11 (pLuc2) during millet seed fermentation Millet seeds were soaked in water in a 1:1 ratio (100 g: 100 mL) and set at room temperature overnight. The seeds were washed with water and 100 mL of water was finally added. The mixture was blended and divided into 3 portions. The overnight cultures of L. plantarum ULAG11 and L. plantarum ULAG11 (pLuc2) were separately inoculated in each portion with 1% (v/v) as a final concentration. At the indicated times (0, 3, 6, 9, and 24 h), each 2 mL of the fermented matrix was sampled, and viable cell count, pH, and luminescence were measured.

Results and Discussion Transformation The L. plantarum ULAG11 strain was transformed with pLuc2. The transformation was confirmed by PCR using a specific primer set lucF (5’-TCAAAGAGGCGAACTGTGTG-3’) and lucR (5’-TTTTCCGTCATCGTCTTTCC3’) targeting a partial region of the luciferase gene in pLuc2. From the PCR, the target PCR product (333 bp) http://www.kosfaj.org/

Monitoring of Bioluminescent L. plantarum

was amplified (data not shown). Bioluminescence of L. plantarum ULAG11 (pLuc2) Exponential phase L. plantarum ULAG11 (pLuc2) cells cultured in MRS broth produced a luminescent signal measured as 831 RLU (relative luminescence units), whereas the negative control L. plantarum ULAG11 cells did not produce a signal (0 RLU), indicating that the luciferase gene was properly expressed in the recombinant strain (data not shown). Change of luminescence during cultivation The changes in luminescent intensity during cultivation are shown in Fig. 1. The growth rate of L. plantarum ULAG11 (pLuc2) was slightly lower than that of L. plantarum ULAG11 in MRS broth, but this difference was not significant. The growth rate of L. plantarum ULAG11 (pLuc2) in MRS broth was similar to that in MRS broth supplemented with 5 µg/mL of erythromycin. During culture, the negative control L. plantarum ULAG11 strain produced very low levels of luminescent signals (180 RLU). The highest luminescent signals (2861 and 2858 RLU, respectively) were produced in the mid-exponential phases of L. plantarum ULAG11 (pLuc2) cultured in MRS broth and MRS broth supplemented with erythromycin. Use of antibiotic pressure for improving the luminescent signal did not work in this case. The luciferase structural gene in pLuc2 is linked to the P32 promoter from the pMG36e lactococcal expression vector where the promoter is transcribed constitutively, indicating that enzyme production is dependent on cell growth (Eom et

al., 2015; van de Guchte et al., 1989). Cronin et al. (2008) reported that Bifidobacterium breve UCC2003 transformed with pLuxMC3, where the luxABCDE operon is linked to an optimized constitutive promoter (Phelp), produced stable luminescent signals until the stationary phase of growth, with the highest level of the signal in the midexponential phase, which is consistent with our result. Additionally, bioluminescent signals of bacterial species harboring the lux operon decline at stationary phase of in vitro culture, which is caused by decreased metabolic activity (Boyandin and Popova, 2003; Cronin et al., 2008; Francis et al., 2001). Matrix effect Detection sensitivity of bioluminescent L. plantarum ULAG11 (pLuc2) was the highest in PBS, followed by whole milk and MRS broth, indicating that the matrix is one of the important factors for sensitivity (Fig. 2). The luminescent signals of the two-fold diluted samples in PBS, whole milk, and MRS broth were 111, 78, and 40 RLU, respectively. Even though the slope of trend line for MRS broth was the most gradual, the signal strength was the lowest when compared with those of other samples. These results suggest that for optimal sensitivity of the bioluminescent bacteria from a complex food matrix should be washed and diluted in PBS before the measurement of luminescence. Monitoring of L. plantarum ULAG11 (pLuc2) during millet seed fermentation Millet seed is fermented to produce products such as kunu-zaki that is widely consumed by rural African populations. This is a natural fermentation product that con-

Fig. 1. Optical density (A) and luminescence (B) of Lactobacillus plantarum ULAG11 (pLuc2) during cultivation. L. plantarum ULAG11 was cultured in MRS broth and L. plantarum ULAG11 (pLuc2) was cultured in MRS or MRS Em (5) (supplemented with 5 μg/mL of erythromycin). The test was replicated and the average values were presented with standard deviations.



Korean J. Food Sci. An., Vol. 37, No. 1 (2017)

Fig. 2. Detection sensitivity of bioluminescent Lactobacillus plantarum ULAG11 (pLuc2) in PBS (A), MRS broth (B), and whole milk (C).

tains many different types of endogenous bacteria including LAB (Oguntoyinbo and Narbad, 2012). During millet seed fermentation, only background signals were detected from the millet seed sample without inoculation and with inoculation of L. plantarum ULAG11, whereas the signal from the sample with L. plantarum ULAG11 (pLuc2) was gradually increased until 9 h (Fig. 3A), which is compatible with a gradual increase in the viable cell count of the

strain (Fig. 3D). Furthermore, an additional increase in the signal was predicted between 9-24 h since the viable cell count at 24 h was drastically increased (Fig. 3D). As mentioned above, millet seeds had harbored their own LAB strains and the viable cell count during fermentation was increased and it reached a similar level as in the other samples at 24 h (Fig. 3C). Addition of the LAB starter cultures accelerated the drop in pH which is a beneficial

Fig. 3. Measurement of luminescence (A), pH (B), and viable cell count of LAB (C, D) during millet seed fermentation where Lactobacillus plantarum ULAG11 or L. plantarum ULAG11 (pLuc2) was inoculated as a starter culture. At 24 h, colony was not detected for Millet_ULAG11 when 103 diluent of the sample was used. The test was triplicated and the average values were presented with standard deviations.



Monitoring of Bioluminescent L. plantarum

fermentation outcome (Fig. 3B). It is not difficult to track a specific strain in pure culture, but there is difficulty in monitoring the target strain in a complex product derived from mixed fermentation. To differentiate the target strain from the other microorganisms in these fermentations, antibiotic resistance genes can be used for specific detection of recombinant strains based on the culture method. Eom et al. (2008) developed a random integration system using a chloramphenicol acetyltransferase gene for monitoring a Leuconostoc mesenteroides strain as a starter culture in kimchi fermentation, and the strain was successfully monitored during the fermentation period. However, in this case, a pretest for confirming that there is no antibiotic resistant strain in the natural microflora needs to be performed. The culture based method also has some drawbacks since it is laborious and time-consuming. Therefore, other efficient methods for detection of a target bacterial strain, such as a starter culture in complex microflora, are necessary. Bioluminescent labeling of LAB strains can be a solution since most of the natural LAB strains cannot produce a luminescent signal, which enables us to detect only the bioluminescent recombinant target strain. In this study, we applied the labeling system to the L. plantarum strain as a model case and successfully detected it in millet seed fermentation where the natural microflora co-existed. The strategy can be broadly used in food and dairy sciences.

Acknowledgements The research was supported by a grant from the Academic Research Program of Korea National University of Transportation in 2014. The authors thank to Mrs. Nwanneka Akinyemi who worked at the Institute of Food Research (UK) as a visiting student for assistant with fermentation.

References 1. Ammor, M. S. and Mayo, B. (2007) Selection criteria for lactic acid bacteria to be used as functional starter cultures in dry sausage production: An update. Meat Sci. 76, 138-146. 2. Boyandin, A. N. and Popova, L. Y. (2003) Expression of luxgenes as an indicator of metabolic activity of cells in model ecosystem studies. Adv. Space Res. 31, 1839-1845. 3. Cronin, M., Sleator, R. D., Hill, C., Fitzgerald, G. F., and van Sinderen, D. (2008) Development of a luciferase-based reporter system to monitor Bifidobacterium breve UCC2003 persistence in mice. BMC Microbiol. 8, 161.


4. Daniel, C., Poiret, S., Dennin, V., Boutillier, D., Lacorre, D. A., Foligné, B., and Pot, B. (2015) Dual-color bioluminescence imaging for simultaneous monitoring of the intestinal persistence of Lactobacillus plantarum and Lactococcus lactis in living mice. Appl. Environ. Microbiol. 81, 5344-5349. 5. D'Argenio, V. and Salvatore, F. (2015) The role of the gut microbiome in the healthy adult status. Clin. Chim. Acta 451, 97-102. 6. de Vos, W. M. (2011) Systems solutions by lactic acid bacteria: from paradigms to practice. Microb. Cell Fact. 10, S2. 7. Eom, H. J., Park, J. M., Seo, M. J., Kim, M. D., and Han, N. S. (2008) Monitoring of Leuconostoc mesenteroides DRC starter in fermented vegetable by random integration of chloramphenicol acetyltransferase gene. J. Ind. Microbiol. Biotechnol. 35, 953-959. 8. Eom, J. E., Ahn, W. G., Her, S., and Moon, G. S. (2015) Construction of bioluminescent Lactobacillus casei CJNU 0588 for murine whole body imaging. Food Sci. Biotechnol. 24, 595-599. 9. Francis, K. P., Yu, J., Bellinger-Kawahara, C., Joh, D., Hawkinson, M. J., Xiao Purchio, G. F., Caparon, M. G., Lipsitch, M., and Contag, P. R. (2001) Visualizing pneumococcal infections in the lungs of live mice using bioluminescent Streptococcus pneumoniae transformed with a novel gram-positive lux transposon. Infect. Immun. 69, 3350-3358. 10. Galland, L. (2014) The gut microbiome and the brain. J. Med. Food 17, 1261-1272. 11. Gory, L., Montel, M. C., and Zagorec, M. (2001) Use of green fluorescent protein to monitor Lactobacillus sakei in fermented meat products. FEMS Microbiol. Lett. 194, 127-133. 12. Higashikawa, F., Noda, M., Awaya, T., Nomura, K., Oku, H., and Sugiyama, M. (2010) Improvement of constipation and liver function by plant-derived lactic acid bacteria: a doubleblind, randomized trial. Nutrition 26, 367-374. 13. Karimi, S., Ahl, D., Vågesjö, E., Holm, L., Phillipson, M., Jonsson, H., and Roos, S. (2016) In vivo and in vitro detection of luminescent and fluorescent Lactobacillus reuteri and application of red fluorescent Cherry for assessing plasmid persistence. PLoS One 11, e0151969. 14. Katz, J. A. (2006) Probiotics for the prevention of antibioticassociated diarrhea and Clostridium difficile diarrhea. J. Clin. Gastroenterol. 40, 249-255. 15. Moon, G. S., Lee, Y. D., and Kim, W. J. (2008) Screening of a novel lactobacilli replicon from plasmids of Lactobacillus reuteri KCTC 3678. Food Sci. Biotechnol. 17, 438-441. 16. Morelli, L. (2014) Yogurt, living cultures, and gut health. Am. J. Clin. Nutr. 99, 1248S-1250S. 17. Ninomiya, K., Yamada, R., Matsumoto, M., Fukiya, S., Katayama, T., Ogino, C., and Shimizu, N. A. (2013) Image analyzing method to evaluate in situ bioluminescence from an obligate anaerobe cultivated under various dissolved oxygen concentrations. J. Biosci. Bioeng. 115, 196-199. 18. Oguntoyinbo, F. A. and Narbad, A. (2012) Molecular characterization of lactic acid bacteria and in situ amylase expression during traditional fermentation of cereal foods. Food


Korean J. Food Sci. An., Vol. 37, No. 1 (2017)

Microbiol. 31, 254-262. 19. Phumkhachorn, P., Rattanachaikunsopon, P., and Khunsook, S. (2007) Use of the gfp gene in monitoring bacteriocin-producing Lactobacillus plantarum N014, a potential starter culture in ham fermentation. J. Food Prot. 70, 419-424. 20. Riaz Rajoka, M. S., Shi, J., Zhu, J., Shao, D., Huang, Q., Yang, H., and Jin, M. (2017) Capacity of lactic acid bacteria in immunity enhancement and cancer prevention. Appl. Microbiol. Biotechnol. 101, 35-45. 21. Sanz, Y., Nadal, I., and Sánchez, E. (2007) Probiotics as drugs against human gastrointestinal infections. Recent Pat. Antiinfect. Drug Discov. 2, 148-156. 22. Tsai, Y. T., Cheng, P. C., and Pan, T. M. (2012) The immunomodulatory effects of lactic acid bacteria for improving imm-


une functions and benefits. Appl. Microbiol. Biotechnol. 96, 853-862. 23. Tsai, Y. T., Cheng, P. C., and Pan, T. M. (2014) Anti-obesity effects of gut microbiota are associated with lactic acid bacteria. Appl. Microbiol. Biotechnol. 98, 1-10. 24. van de Guchte, M., van der Vossen, J. M., Kok, J., and Venema, G. (1989) Construction of a lactococcal expression vector: Expression of hen egg white lysozyme in Lactococcus lactis subsp. lactis. Appl. Environ. Microbiol. 55, 224-228. 25. Yu, Q. H., Dong, S. M., Zhu, W. Y., and Yang, Q. (2007) Use of green fluorescent protein to monitor Lactobacillus in the gastro-intestinal tract of chicken. FEMS Microbiol. Lett. 275, 207-213.


Monitoring of Bioluminescent Lactobacillus plantarum in a Complex Food Matrix.

A bioluminescent Lactobacillus plantarum (pLuc2) strain was constructed. The luminescent signal started to increase during the early exponential phase...
957KB Sizes 0 Downloads 11 Views